+86 0371 8654 9132

flotation copper tests

Flotation Test of a High Silica Copper Oxide Ore in Yunnan

Abstract—In this paper, the beneficiation of a copper oxide ore of Yunnan was investigated through bench-scale froth flotation tests. During the froth flotation, the conditions that effect on the flotation performance was researched, including the grinding fineness and the dosage of lime as

Read More
Laboratory Flotation Testing – An Essential Tool for Ore ...

2016-11-22  after two minutes of flotation. A faster floating copper porphyry flotation test, however, may finish in five minutes and a first concentrate may need to be collected after 20 seconds. Depending on one’s circumstances, some deviation may be required from the recommended test

Read More
Feasibility Study of Differential Flotation of Cu–Pb–Zn ...

2020-8-28  In this research, flotation of copper, lead and zinc minerals from a copper oxide–sulfide ore was studied. The identification tests showed that the sample is a mixture of quartz, chalcopyrite, galena, cerussite, hemimorphite and iron oxide minerals with 5.04% CuO, 1.61% PbO, 2.07% ZnO and 56.40% SiO 2. The experimental design methodology (RSM) was conducted to investigate the effect of

Read More
Optimization of reagent dosages for copper flotation

2010-12-29  reagents on copper flotation performance are determined. The main steps in the current work are: 1) designing and performing of experiments on laboratory scale; 2) analysis of experimental results to determine the significant factors influencing the copper grade and recovery in the rougher stage; 3) determination of copper

Read More
Optimization of the flotation of copper smelter slags from ...

2021-3-26  flotation tests which were performed on slag samples from three different sources (TSL furnace, copper converters, reverberatory furnace) to recover the copper minerals. A range of commercial flotation reagents including xanthates, dithiophosphates, mercaptobenzothiazole,

Read More
Analysis of flotation rate distributions to assess erratic ...

2020-4-1  The rougher separation of Cu/Pb was conducted in batch flotation tests. The samples were crushed in a laboratory jaw-crusher to obtain 100% passing 3.35 mm. The crushed samples were blended, riffled and split to obtain 500 g-batches for grinding and flotation tests. Minor adjustments were required to obtain the set feed mass.

Read More
1 Froth Flotation – Fundamental Principles

2009-8-27  Table 1: Grade/recovery performance of a hypothetical copper ore flotation process. Product % Weight % Cu Assay Feed 100 2.09 Concentrate 10 20.0 Tailings 90 0.1 (a) From Table 1, the Ratio of Concentration can be calculated as F/C = 100/10 = 10. If only assays are available, the ratio of concentration equals (20 – 0.1)/(2.09 – 0.1) = 10 ...

Read More
Separation efficiency improvement of a low grade copper ...

2017-12-21  copper flotation circuit. The techniques used for diagnosis include: quantitative mineralogical evaluation of key streams, flotation circuit surveys, floatability component model fitting and simulation, and the application of dilute batch flotation tests.

Read More
AN INVESTIGATION OF COPPER RECOVERY FROM A

2010-1-19  The flotation of a natural porphyry copper ore with bornite and malachite was investigated via fundamental work with pure minerals and a bench-scale testing regime. The processing of the test ore was problematic due to a mineral assemblage that caused prevalent slime generation.

Read More
The Effect of Oxidation on the Flotation Behaviour of ...

2016-6-14  In the flotation process, a number of reagents are seen as a means ofdepressing pyrrhotite. However, the complex surface chemistry of the nickel-copper ores appears to challenge the effectiveness and consistency of these reagents; in many cases, testing indicates that pyrrhotite continues to float when it is not supposed to.

Read More
Flotation Test of a High Silica Copper Oxide Ore in Yunnan

Abstract—In this paper, the beneficiation of a copper oxide ore of Yunnan was investigated through bench-scale froth flotation tests. During the froth flotation, the conditions that effect on the flotation performance was researched, including the grinding fineness and the dosage of lime as

Read More
THE EVALUATION OF A COPPER FLOTATION PLANT

2004-10-13  flotation tests. In these tests, the copper recovery was increased from 89.79% to 94.56 for coarse (d80= +312 µm) and fine (d80= -312 µm) feed respectively. The concentrate Cu grade was reached to 26.07% after 3 stages cleaning for fine feed. This

Read More
Optimization of the flotation of copper smelter slags from ...

2021-3-26  flotation tests which were performed on slag samples from three different sources (TSL furnace, copper converters, reverberatory furnace) to recover the copper minerals. A range of commercial flotation reagents including xanthates, dithiophosphates, mercaptobenzothiazole,

Read More
Study of Flotation Parameters for Copper Recovery from ...

2020-4-1  For flotation tests different conditions were explored in order to search for maximum recovery of copper. The aim of these flotation tests was to obtain theconcentrate with a high grade of As and high recovery of Cu. It has been established that butyl xanthate (BX) was uses as a collector at the dosage of 100 g/t , the optimum flotation time was 16

Read More
Separation efficiency improvement of a low grade copper ...

2017-12-21  flotation tests conducted on various concentrate streams around the plant. Figure 3 Copper recovery as a function of mass recovery - dilution cleaning tests It is evident that with all streams re-floated, there is a significant upgrading achieved

Read More
A Comparative Study of Kinetics of Flotation of a Copper ...

2012-11-30  similar study on the flotation of a copper-zinc ore using arylhydroxamic acids, Natarajan and Nirdosh (2006) observed flotation of sphalerite without activation by copper suphate and highlighted the ... * For HCNPHA tests PAX was replaced by HCNPHA (12 mg in grinding and 88 mg in

Read More
Combined Effect of Operating Parameters on Separation ...

2019-3-20  kinetic parameters of the copper flotation process. For this purpose, flotation tests were conducted with different condi-tions of pulp density, collector and frother dosages, and prep-arationandfrothcollectiontime.Thisstudywascarriedouton a Sungun porphyry copper

Read More
Effect of bacterial conditioning and the flotation of ...

2009-1-26  copper in 9K was increased up to 1 g/l, at end of the adaptation process. Flotation Tests The flotation tests were carried out in a Hallimond tube and Denver type flotation machine. In Hallimond tube tests, 1 g sample was used having –210+38 µm. In the study of the oeffect of

Read More
Copper Sulphide Ore Reagents For Copper Flotation

The ore sample was ground to below 200 ?m and then collective and selective sulphide flotation tests were performed flotation tests, depression was achieved using non-toxic reagents and consequently individual copper, lead and zinc concentrates assaying 31.68% cu, 67.69% pb, 49.79% zn were obtained with 72, 80 and 57% metal recoveries. Live Chat

Read More
AN INVESTIGATION OF COPPER RECOVERY FROM A

2010-1-19  The flotation of a natural porphyry copper ore with bornite and malachite was investigated via fundamental work with pure minerals and a bench-scale testing regime. ... ore was problematic due to a mineral assemblage that caused prevalent slime generation. Fundamental adsorption, micro-flotation and Eh-pH tests were conducted on pure minerals ...

Read More
Flotation Test of a High Silica Copper Oxide Ore in Yunnan

Abstract—In this paper, the beneficiation of a copper oxide ore of Yunnan was investigated through bench-scale froth flotation tests. During the froth flotation, the conditions that effect on the flotation performance was researched, including the grinding fineness and the dosage of lime as

Read More
Research on Flotation Tests of Sulfide Copper Ore

The mineral processing flow sheet and reagent system of flotation copper minerals from a large copper-iron deposit in Yunnan were fully investigated. The results indicate that the optimum conditions for flotation of copper minerals from the material were identified as grinding fineness of 85%, dosage of CaO at 2000g/t , dosage of Na2S at 200 g/t, dosage of butyl xanthate 40g/t.

Read More
THE EVALUATION OF A COPPER FLOTATION PLANT

2004-10-13  flotation tests. In these tests, the copper recovery was increased from 89.79% to 94.56 for coarse (d80= +312 µm) and fine (d80= -312 µm) feed respectively. The concentrate Cu grade was reached to 26.07% after 3 stages cleaning for fine feed. This

Read More
Flotation Test of a High Silica Copper Oxide Ore in

In this paper, the beneficiation of a copper oxide ore of Yunnan was investigated through bench-scale froth flotation tests. During the froth flotation, the conditions that effect on the flotation performance was researched, including the grinding fineness and the dosage of lime as depressant, sodium sulphide as regulator, sodium n-butylxanthate as...

Read More
Study of Flotation Parameters for Copper Recovery from ...

2020-4-1  For flotation tests different conditions were explored in order to search for maximum recovery of copper. The aim of these flotation tests was to obtain theconcentrate with a high grade of As and high recovery of Cu. It has been established that butyl xanthate (BX) was uses as a collector at the dosage of 100 g/t , the optimum flotation time was 16

Read More
Recovery of copper and cobalt in the comparative

2020-4-16  flotation tests in order to recovery copper and cobalt. This paper investigates the effect of potassium amyl xanthate (PAX) and sodium dibutyl dithiophosphate (DANA) performance on both copper and cobalt recovery in single roughing flotation. The effect of pH on the flotation is proposed. Some parameters were

Read More
A Comparative Study of Kinetics of Flotation of a Copper ...

2012-11-30  similar study on the flotation of a copper-zinc ore using arylhydroxamic acids, Natarajan and Nirdosh (2006) observed flotation of sphalerite without activation by copper suphate and highlighted the ... * For HCNPHA tests PAX was replaced by HCNPHA (12 mg in grinding and 88 mg in

Read More
Combined Effect of Operating Parameters on Separation ...

2019-3-20  kinetic parameters of the copper flotation process. For this purpose, flotation tests were conducted with different condi-tions of pulp density, collector and frother dosages, and prep-arationandfrothcollectiontime.Thisstudywascarriedouton a Sungun porphyry copper

Read More
Separation efficiency improvement of a low grade copper ...

2017-12-21  flotation tests conducted on various concentrate streams around the plant. Figure 3 Copper recovery as a function of mass recovery - dilution cleaning tests It is evident that with all streams re-floated, there is a significant upgrading achieved

Read More
The effect of a novel depressant on the separation of talc ...

2019-1-21  × 90mm ball mill at a pulp density of 65% by weight. The bench-scale flotation tests were performed in XFD-63 flotation cell (self-aeration), 3000 cm. 3. for rougher flotation and 1000 cm. 3. for cleaner flotation, and 500 cm. 3. for flotation separation of copper/nickel minerals, respectively. The Cu/Ni bulk flotation

Read More